• Welcome Visitor! Please take a few seconds and Register for our forum. Even if you don't want to post, you can still 'Like' and react to posts.

'86 Ranger 2.3 - Engine Cut-Out Symptom


Mylesofsmyles

New Member
Joined
Oct 28, 2013
Messages
210
Reaction score
1
Points
0
Location
San Francisco, CA
Transmission
Automatic
It's an intermittent issue, that's never fully stalled the motor.

It was very intermittent before, a week or a few ago...now it's more often.

I'll be driving through town, low speed, low load, and the engine cuts out for only an instant at a time...seems similar to when my ignition switch failed, or a bad fuel pump.

Both Prepump, main pump, filter, FPR & injector o-rings replaced within the past 13 month.

Where and how can I start looking? What else could it be?
 


RonD

Official TRS AI
TRS Technical Advisor
Joined
Jun 2, 2012
Messages
25,292
Reaction score
8,297
Points
113
Location
canada
Vehicle Year
1994
Make / Model
Ford
Transmission
Manual
Intermittent is of course a pain to ID until total failure, but that is a pain as well.
Big 3
Compression
spark
fuel

I would rule out compression, unlikely for symptom

'86 2.3l will still have the TFI spark system with distributor.
Good read here on testing that system: http://www.therangerstation.com/tech_library/TFI_Diagnostic.shtml
Might find a marginal wire during testing

You could get/rent a fuel pressure gauge and test pressure.
If you have a 12v test light you could hook it up to the inertia switch in the passenger footwell, this would tell you if fuel pump power is being cut while driving, i.e. bad wire or Fuel Pump Relay.
 

Mylesofsmyles

New Member
Joined
Oct 28, 2013
Messages
210
Reaction score
1
Points
0
Location
San Francisco, CA
Transmission
Automatic
I wondered about the TFI, but that's still only 13-14 months old...

I cleaned up cap & rotor...going to go check that fuel pump wires are on tight, and give it a try.
 

RonD

Official TRS AI
TRS Technical Advisor
Joined
Jun 2, 2012
Messages
25,292
Reaction score
8,297
Points
113
Location
canada
Vehicle Year
1994
Make / Model
Ford
Transmission
Manual
If you have a tachometer watch it closely during a stall out, yes RPMs drop during the stall but not by that much.
Tach gets it's signal from Coil "-" which is controlled by TFI, sudden drop on the meter(tach is an electric meter) could mean electrical issue.

And as a long shot, is this a manual or automatic?
If automatic could transmission be disengaging?
RPMs would go up though, if foot was on the gas pedal
 

Mylesofsmyles

New Member
Joined
Oct 28, 2013
Messages
210
Reaction score
1
Points
0
Location
San Francisco, CA
Transmission
Automatic
Manual trans....M50d swap, back in May '14

Tach seems stable.

FYI...I did find a loose terminal on high pressure pump....tightened it, and secured.

With the cleaned cap & rotor, and tightened fuel pump terminal, car drove better for the first couple miles, now symptom is back and worse than ever
 

Haywire6000

Member
RBV's on Boost
Joined
Apr 6, 2013
Messages
423
Reaction score
1
Points
18
Location
Lewiston Maine
Vehicle Year
1993
1997
Make / Model
Ford
Engine Size
2.3 Turbo Four Plug Head
Transmission
Manual
Mine 93 would do this. It was a bad connection at the fuse box for the fuel pump.
 

Mylesofsmyles

New Member
Joined
Oct 28, 2013
Messages
210
Reaction score
1
Points
0
Location
San Francisco, CA
Transmission
Automatic
Threw the parts cannon at it...

Just got back from the parts house with new wires, cap, rotor, coil & MAP sensor...

So far, so good.
 

Sponsored Ad


Sponsored Ad

Staff online

Members online

Today's birthdays

Member & Vendor Upgrades

For a small yearly donation, you can support this forum and receive a 'Supporting Member' banner, or become a 'Supporting Vendor' and promote your products here. Click the banner to find out how.

Latest posts

Truck of The Month


Kirby N.
March Truck of The Month

Recently Featured

Want to see your truck here? Share your photos and details in the forum.

Follow TRS On Instagram

TRS Events

25th Anniversary Sponsors

Check Out The TRS Store


Sponsored Ad


Sponsored Ad

Sponsored Ad


Amazon Deals

Top